Volvo V40 MOT failure rate and common faults
94,591 Volvo V40 cars aged 3 to 20 took their MOT in 2025, and 27.8% failed at the first attempt. An average car of the same age failed 25.9% of the time, which makes the Volvo V40 7% more likely to fail than the typical car on the road. Here is what fails, and which years to look for.
27.8%
failed first time
94,591 MOT tests in 2025
+7%
vs same age average
average car of this age mix: 25.9%
151 of 208
age adjusted rank
among cars; 1 fails least
124.7
dangerous defects per 1,000
same age average: 98.1
What fails on a Volvo V40 MOT
Failure items recorded per 1,000 tests, by part of the car, set against an average car with exactly the same spread of ages. A figure well above average is a weak spot worth checking before you buy.
The most common Volvo V40 MOT failures
The individual failure items testers recorded most often, per 1,000 tests.
| Failure item | Area | Per 1,000 tests |
|---|---|---|
| Coil spring: fractured or broken | Suspension | 72.9 |
| Tread depth below requirements of 1.6mm | Tyres | 33.0 |
| Tyres: has ply or cords exposed | Tyres | 31.2 |
| Brake pads: less than 1.5 mm thick | Brakes | 29.1 |
| Drive shafts: constant velocity boot split or insecure, no longer prevents the ingress of dirt | Body, chassis, exhaust and drive shafts | 24.2 |
| Tyres: has a cut in excess of the requirements deep enough to reach the ply or cords | Tyres | 20.3 |
| Position lamp: not working | Lights and electrics | 19.3 |
| Anti-lock braking system: warning lamp indicates an ABS fault | Brakes | 17.8 |
| Headlamp aim: too low | Lights and electrics | 16.9 |
| Wipers: does not clear the windscreen effectively | Windscreen, wipers and mirrors | 13.8 |
Volvo V40 MOT failure rate by year
Every car fails more often as it ages, so each registration year is compared with the average for all cars of the same age. Years with fewer than 500 tests are left out.
| First registered | Tests | Failed | Same age average | Average mileage |
|---|---|---|---|---|
| 2019 | 8,201 | 19.4% | 16.5% | 44,500 |
| 2018 | 12,954 | 21.1% | 19.1% | 53,400 |
| 2017 | 13,525 | 22.0% | 21.8% | 64,300 |
| 2016 | 15,337 | 26.8% | 25.1% | 74,200 |
| 2015 | 15,381 | 32.4% | 28.1% | 85,700 |
| 2014 | 15,870 | 33.0% | 31.4% | 94,800 |
| 2013 | 11,049 | 34.1% | 34.3% | 105,600 |
| 2012 | 2,253 | 38.1% | 36.6% | 112,200 |
Advisories to look for in a Volvo V40's MOT history
An advisory is a tester's warning that something is wearing but has not failed yet. These are the ones written most often on the Volvo V40, per 1,000 tests. If the car you are looking at has one of these, ask whether it has been fixed since.
- Tread depth: worn close to legal limit/worn on edge314.4
- Brake pads: wearing thin131.4
- Tyres: slightly damaged/cracking or perishing123.9
- Brake discs: worn, pitted or scored, but not seriously weakened103.6
- Suspension arms: pin or bush worn but not resulting in excessive movement89.9
- Brake discs: worn, but not excessively36.6
Checking a used Volvo V40 before you buy
Against cars of the same age, the Volvo V40 fails more often than average on tyres and body, chassis, exhaust and drive shafts. Start there.
Tyres
Check the tread across the full width of every tyre, inner edge included. Uneven wear points to worn suspension or out of line steering geometry.
Body, chassis, exhaust and drive shafts
Turn the steering to full lock and look behind each front wheel: the rubber boots on the drive shafts should be whole, with no grease sprayed around. Then get down with a torch and check the exhaust hangers, sills, floor and subframes for rust.
Averages only take you so far. The specific car's MOT history shows whether it has already failed on any of these, how often advisories were ignored, and whether the mileage climbs steadily from test to test. Read our guide to reading a car's MOT history before you go to view it.
Fuel mix of the Volvo V40 cars tested: Diesel 64%, Petrol 36%. Average age at test 9.3 years, average recorded mileage 77,300.
Volvo V40 MOT questions
What is the Volvo V40 MOT failure rate?
27.8% of Volvo V40 cars failed their first MOT test of 2025, from 94,591 tests on vehicles aged 3 to 20. An average car with the same age mix failed 25.9% of the time, so the Volvo V40 was 7% more likely to fail.
What fails most often on a Volvo V40 MOT?
Suspension caused the most failure items, at 114 per 1,000 tests. The single most common failure item was "Coil spring: fractured or broken", recorded 72.9 times per 1,000 tests.
Which Volvo V40 year has the best MOT record?
Measured against cars of the same age, 2013 registrations did best: 34.1% failed against an average of 34.3% for cars that age. Older cars always fail more often, so compare a year with its age group rather than with newer cars.
Does this tell me whether a particular Volvo V40 will pass?
No. These are averages across every Volvo V40 tested in 2025. The car in front of you has its own record: its full MOT history shows every pass, failure and advisory it has had, and it is free to view by registration.
Other Volvo models
- Volvo XC6019.9% failed
- Volvo XC4010.0% failed
- Volvo XC9023.5% failed
- Volvo V6022.5% failed
- Volvo V7033.1% failed
- Volvo V5044.8% failed
Ranked close to the Volvo V40
- Hyundai ix20rank 148
- Vauxhall Crosslandrank 149
- Hyundai Santa Ferank 150
- Nissan Leafrank 152
How these figures are calculated
Source: DVSA Anonymised MOT tests and results, 2025 release. We count first tests of cars and small vans (class 4) aged 3 to 20, so a car that fails and is retested is counted once. A failure includes faults fixed and passed within the same visit. The same age average weights the national failure rate for each age by how many Volvo V40 cars of that age were tested, so a model is never penalised for having an older fleet. Make and model are as recorded at the test; trim levels are combined. Full method and rankings.
Contains public sector information licensed under the Open Government Licence v3.0.